We suggest you to surf our . My bud said the bike ran fine before sitting. Fully charged battery..new plugs..new oildrained petrol and added new..clean fuel pump..cleaned injectors..clean air filter..checked codes in dealer mode and get c00 which means evrything is ok. I went out to start it Friday and it started right up. Anyway.I dont have a clear cut answer for you. Do you have a lithium battery installed on the motorcycle? It could be locked up. I checked my statorand it was dead on spec in all three positions. I replaced the transistors on the spark unit. The coils look good ohms are ok on prim and sec. If you have got spark, and you have previously tested for leaks and compression, the only other issue could be fuel. Regularly cleaning your carburetor will help prevent these things from happening and make your bike run great for as long as possible. I decided to sell this bike, but it will not start. Bot a charger and hooked it up. Its just about to start. Has me sobummed..and I aint a dummy or ham handed. I have an 02 gaze 1000 that would start fine. I gave a very thorough explaination of what was going on. There are few things that are more disappointing than getting psyched up to go riding only to be hit with realization that your motorcycle wont start. I would look a little more into the neutral . Hi Keith, I would definitely start by cleaning the carbs. Exessive wear or something making the gears stuck? If you have no experience, it can be puzzling to figure out. Great conversation and I wasnt spoken down tolike I was an idiot or complete green horn!! Oh and if it helps at all, my bike is a 1986 Honda Shadow VT700. I have power to cluster, all lights work fine, horn is strong. i have a 1978 Kawasaki kz750, the engine wont fire up but will sit there and try to and tick while trying to turn on. I just dont understand could you help me. Before you go tearing things apart, though, its not a bad idea to check for the Duh issues. 320-358-3409 or by email at techsupport@denniskirk.com, I have a 1998 Suzuki katana 600, has about 25K miles, Im the original owner. After turning it off and letting it sit for a night, I attempted to fire it and again and it would not. Is it a venting problem? Your carburetor has a very important job to perform and if things are blocking it from doing its job, your bike will not run. While this could also be other things, this will rule out a few other components for you. Could this be the culprit? Once the bike gets running its acts fine and will fire right up. no noise at all. Kickstand Is up kill switch is off. You want the plunger to slide freely. The light inside the tachometer flickers. Another fuel issue is that your bike might not start because it is flooded. If it helps, I just installed a new cdi, so that is not an issue. I have a GSXR 1000 K5 Suzuki.Last night I webt riding and when I got back home I parked in yhe yard switched of the bike to close the gates.when I want to start my bike again it doesnt want to start.I have done the duh issues.when I switch the ignition on.all my lights go on.but my petrol pump doesnt reset/buildibg pressure. Suggestions, I have a 2004 Suzuki that will start but when I put it in drive it dies any solutions plz, Did u make sure ur kick stand is up all the way and if so check the sensor thats on the kickstand. thanks. With no fuel, the engine will not run at all. Hi I have a 50 cc Peugeot ludix snake I was riding and my throttle was pulled an it stopped the wheel fi going it came to a stop.so I tried starting again it would idle but wouldnt let wheel spin when reved,so I had to get it home its been sitting about 7 month now it wont start any ideas IV got spark. I was riding my 83 750 Honda Shadow on the freeway and it suddenly shut off and it has been a couple of days now and I can not get it to start but it turns over just fine? Please time Running out. Theres still more to check. can coil be d problem? Ive been fiddling with it for most of the winter months. Any wisdom would be greatly appreciated. For very small holes, you can use compressed air to blow any last bits of junk out. Make sure that everything gets put back together correctly. When I took it off the lift, the rear tire was locked. However, the problem is most likely electrical. Hi I have a 2006 Suzuki blvd c50. Im getting gas an spark but wont start. I need to get it to start so I can clean the jets any suggestions? You can try a new spark plug, the spark may not be strong enough. I took the bike to the shop and they were lost, they couldnt figure out why my bike wouldnt start. Where to start. Cheers Andy. It may not display this or other websites correctly. New ignition switch on order. I did a mod 3 thinking that would solve my labored starting after I bought a gbatt. For more help troubleshooting, contact our tech team at 320-358-3409 or by email at techsupport@denniskirk.com. Everything powers up but bike will not turn over. Been running fine so far,,but iIve just owned it for about a week,,,It does need a good tuneup,it sat for awhile before I bought it! I have since stripped it right back, iyt of frame. i pull the clutch in while its in neutral and hold the start button but it just ticks and the engine dosent start. Assumed my battery had died because the guy I bought bike from said he had never changed it. Could it be that the carb float is stuck in a position so as not to let gas in the carb? Any advise would be appreciated. It stumbles to 115 and no matter how much throttle i give it its not going any faster. Make sure its not getting flooded. I ment I made it carbureted. please help, Hey there. I had a mechanic buddy.look through my second set of carbsAGAIN. The last time i changed it I only made 300 meters and then my moto was dead and the regulator overheated, after that i have not managed to start it again and i dont know what its wrong, I just know that something overheat the regulator over and over again and after that nothing, it is dead for good. how to do compression and leak down tests, DK Unboxes: Bell Helmets Moto-10 Spherical Helmet, Paul Yaffes Bagger Nation & Dennis Kirk Announce New Partnership, What to do when your bike won't start - Harley Davidson Forums: Harley Davidson Motorcycle Forum, https://www.denniskirk.com/learn/how-to-diagnose-motorcycle, http://ricksmotorsportelectrics.com/part/20-408/ODdZYW1GWjYwMA==. You will want to do a good and thorough job so the bike will continue to work properly. Hi, Sometimes the switch gets moisture in it and will rust/ corrode. Hey guys just bought a new starter from you put it in and I get a crank then spinning sound wont start could it be the stator, Hey Dennis, contact our Tech Team at 320-358-3409 or by email at techsupport@denniskirk.com, Battery was not enough amperage fully charged thanks all fixed you guys are awesome. i would like to know if it helps anyone else please. Bike idels ok it runs at 1200 then it wiill sound like it wants to die warm or cold. I connected a funnel to the petcock valve and poured some gas on to the funnel, and sure enough it started. I have checked all of the fuses, all good. battery charged and new spark plug oil changed fuel full. Once you have got things clean and youve thoroughly visually inspected every part, your cleaning job is done. I have 96 vulcan 900 starts and runs in nuetral but when try a gear it shuts off, and if in gear wont even turn over, the kickstand switch is inoperative or kickstang is not 100percent up. Think this is culpeit. It will take a minute before the necessary vacuum pull has formed again and fuel is flowing through the carb. It has good spark, petcock is on, battery is strong. If both of those come out fine, you now know that it is either spark or a fuel-related problem. Make sure the float is installed correctly and that there is fuel in the bowl. Our tech team can walk you through all of the steps to check each part. i have a similar problem. The mechanic, I spoke with.. name escapes me? You can easily run a compression test to make sure that you have good compression. What do you think? They testedto spec. Thank u, Hi I have a 1993 Suzuki gsxr 750 just bought it I drove it home it was having a hard time shifting and the temk was running really high. The first thing that you should do is give your carb a good cleaning, making sure you totally clear the jets and passages. Not starting. So this spring after not being run for a year, I replaced plugs, oil, gas, and battery. Has new air filter. Now his bike wont start. Fresh oil and gas. Greetings. Then before starting do a dry run. The most common culprit is the float. I unplugged the fuel line from the tank and cranked the bike, fuel came out. By running a leak test, you can verify if there are any. Unread post Ive checked all fuses and they are all good. Start by checking the simple and easy things. Just as satisfying is the deep rumble from the reverse taper . The battery had a tender on it and finally needed to be replaced this spring which I did. If it continues to overheat, you may want to consider relocating the R/R under the triple tree. it seized up , but then after a few more trys , it started but runs very ruff . the bike wont even fire if I put fuel into the cylinder..Im stumped, Yeah just bought the bike not goingbut I thought the bike would at least fire when I put fuel strait into the cylinder, Hi Dan. Engine did not turn over/ no sound or click of any kind. by NorthernPete Fri Oct 18, 2013 5:40 pm, #4 Does it crank over, or is everything dead? Cycle wont climb above 8000 rpm in 1st, 2nd.feelslike it just isnt getting enough fuel at 6000-6500 rpms in 3rd, 4th. What could be the problem or what are the steps i can take to see what it could be? Once your carbs are clean, you will want to make sure that your fuel pump is working properly as well. Hey Sandeep. The bike was off, gas was off everything thats suppose to be off they were all off. still wont fire. Your tech also suggested a smaller main jet. This will cut off the flow of fuel into the engine. Fired up but died while warming up 5 min later never came back.im stumped. Kyle currently works as a mechanical engineer and graduated with a minor in automotive engineering. The battery is brand new, I replaced it and kept a battery tender on it, and the engine turns over. If it stalled while riding check the battery,most likely a connection. They are are solid180 psi. Please help, Hi Juwan, it sounds like you might have a faulty relay. It will not start with the push butto. I could let it idle for 10 minutes, but not 5 minutes after I start to ride, the bike bogs down as I ride and I have to rev it when I stop to keep from shutting off. I have a 1982 Honda CM 250 C and it will not run. Afterward, you will want to wash things off with water to get rid of your cleaning chemicals. You can also take a brush and use that to scrub the parts while they are soaking in the container. Thanks Ryan, ill test out the bike with a new battery and see how it works out. Check your fuses first. I just filled my tank with apple cider vinegar, and now I am letting it sit in a tub. You are now ready to start putting everything back together. so i got a set of NGK CR8E plugs and bam that fixed it!!!!! When my friend and I started taking things apart, I saw that there was a long hairline crack on the cylinder head. Bad choke ?? I have a 1974 TL 125 honda it hasnt been started in 40 years but was running when parked I have restored in the last three months cant get it to fire I have put it in time put a new coil w/t condenser I have new stater a new plug ,new points gap at .14 plug gap at.28 have contact to flywheel,contact to plug and coil ! Mantwisting my mind!! Hello Ryan: You can contact them at 320-358-3409 or by email at techsupport@denniskirk.com, Hi 97cbr900rr. could it be a dead battery or not recharging? Cannon Entities LLC is a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for sites to earn advertising fees by advertising and linking to Amazon.com. Hey I have a buell blast it will turn over but shut right back off and when I spray some starter fluid it will start but want stay on for long. Advice? (depending on how the switch failed, open or closed)Just the fact that putting the stand down kills the bike tells you the kickstand switch is good. But now bike will only run/idle with choke out, push choke in n she dies. There are potentially a lot of different things that could be causing your bike not to start. What do I do please help. Got 4 volts on each coil when cranking. Runs on starting fluid until it burns off. Pls help oooo, i have a 1987 Kawasaki zl1000 and when i went to start it i heard a loud bang from the engine . After this short stutterall fine. That I cant test. Good day. Got some skills!! If not, switch out the plugs to check to see if that makes a difference. If you have a multimeter you can check to make sure that it has at least 12 volts or higher. Make sure that your spark plug is actually connected. I started the bike on the lift (not sure why) and it started. I think I am in for some work trying to get this bike back in running shape. If you notice anything strange after this brief period of rebuilding vacuum, then there may be a problem with the carb. Checked and cleaned every thing.engine getting gas. Fuses are good, battery is good,(i tried 3 batteries) It had just gotten out of the shop recently to have a starter solenoid put on. Motorcycle Repair: Suzuki intruder wont start, intruder 250, eric gorr. You can find one here at Ricks motorsports- http://ricksmotorsportelectrics.com/part/20-408/ODdZYW1GWjYwMA==, E mail me. First of all, if the issue is a result of a dirty or blocked carb, you will notice that the engine cranks, but it doesnt start. Put a new fuel filter in and now it wont start. Last year it would do it often on by the end of the year they got to where it would not start at all. its not air, fuel, spark, or compression 100%. Is there even gas in the tank? Rocdahitman. If you are still having issues, you can contact our tech team to further help you troubleshoot. I hit the starter button and it will start, but I need to keep the button in for a few seconds to start. Turn engine by hand a few times. Also make sure that the bike has good compression. Hi, I have a gsxr400 gk71f. She turned over like there were no spark plugs on. Free shipping for many products! Had compression checked on all 4 cylinders. Fuel lines can dry out and crack. You can also run a leak test to be sure you do not have any air leaks. Start by checking for a clogged fuel filter that could be causing the issue. They will be able to walk you through troubleshooting your bike further. It obviously wont start. If i get on it With the Duh issues resolved and your bike still not starting, its time to investigate further into your engine spark. Honda xr125L. Remember that your bike needs four main things to run. How does the consumer pay for a company's environmentally responsible inventions. YOU ROCK ! Also make sure that the bike is in neutral and that your kickstand is up. What could be causing this issue? Still does not run. They will be able to help you troubleshoot this further. Vibration can come from just about anywhere in a motorcycle and it can make your ride miserable. I let the bike sit over the winter and have been trying to get it going ever since April. I sprayed the ignition switch with contact cleaner thinking maybe it was gummed up, but still nothing. South Korea's Ministry of Education said Monday that six school students were among the dead, including one in middle school. I rode it to work Saturday, Sunday, and yesterday. Please help. Cant figure it out. This bike has only 29 miles on it. Do not be alarmed if you experience this because it is completely normal. Any body have any suggestions. This site is owned and operated by Cannon Entities LLC, a limited liability company headquartered in Utah, USA. When you start here, you can keep tracing it back until you find your ignition or spark issue. My bike had ran out of gas and after filling her up she would not start. Bike does turn over. Replaced it and still nothing is happening. I keep thinkingitll snap to attention after.this next thing.and doest. It will start up if I crank on it for a minute and find the right spot in the throttle, then itll only run as long as I hold the throttle half open and it runs at 6000 rpms. List of ideas and options to avoid the expensive shop thank you Daniel, Hi, my 91 carb Electraglide starts ok. Again, started for a second and died. If so any advice would be helpful! What do you think is the problem ? Please contact the moderators of this subreddit if you have any questions or concerns. And I just replaced my neutral safety switch o ring and front blinkers and now wont start. Suzuki Intruder flasher relay. Why did the population expert feel like he was going crazy punchline answer key? Ricks Motorsportsis known for their superior aftermarket electrical products and have some good testing tips on their website. Why would the fuel pump just stop working like that. Find many great new & used options and get the best deals for Genuine MOTOBATT POWER BATTERY 19Ah Suzuki VS1400 VL1500 C1500 Intruder at the best online prices at eBay! Have a great day. Suzuki intruder won't start? Yes there is a electrical issue! Help! I also voltage tested and it showed nothing out of the ordinary. I have just been givin a motorbike 750 cc wont start has spark and fuel. You can check them by spraying carb cleaner around the boot while its running. Does it not turn over at all? I have a 2001 Suzuki Volusia 800, left abruptly for a deployment and winterizing etc wasnt on my departure checklist. A broken or loose vacuum line can result in too much air being drawn into the combustion chamber, which will alter the air/fuel mixture and not allow the engine to ignite the mixture properly. Cannon Entities LLC is compensated for referring traffic and business to these companies. Tomorrow new spark plugs and cleaning the air filters. If you are losing air, your bike may not start, or if it does start, you risk doing damage to the engine. Now it wont start at all. I also checked it to ground and the AC current. Cool little bike. Have replaced the battery and checked neutral safety switch, it seems to be working fine. Hi, this could be any number of things. Ive.Just.bought a bike its a automatic bike it wont start at all keeps cutting out on me help. Hooked up the cables to my friends truck and it fired up nice.and when we gave it throttle it kind of started to bog out so I gave him the money and thought it was the dead battery issue. Ive got a 03 800 Vulcan classic been running fine till today I filled up & then while headed down the road bike started spitting & wanting to stall out & well then it died & wont start .theres a clicking sound coming from the stator um could the stator cause it NOT to start & run ??? No turning over or anything. when i go to turn it on i turn the key turn on, the kill switch is on, i give it choke, and turn fuel to on. Then let the carb dry. Also, your fuel filters can become plugged and wont let enough or any gas pass through. Replaced stater rectifier n battery due to faulty wires. Got it home, leaked oil, started rough, kept stalling and smoking. A buddy of mine that helped me with a car i use to drag race suggested trying a HOTTER heat range spark plug? So i just stopped turning her over tried again and she started sounded good lots of air flowing so i turned her off and tried again and did the same . Suzuki intruder wont start. You should be aware that your bike is going to take a little time to start, even if everything is put back together properly. Ryan suggested that I call their tech advice hotline. But since he said there was a dead battery issue. CDI ?? And STILL wont start. Don t know what to think. So i was wondering could it just be a bad plug or could it be internal.? But if I go on a ride and stop for a short time it doesnt like to start? If so how should i got about doing this? The first line of your blog check the kill switch. My favorite bike from back in the day. Bike just turns over and over but no start at all . I have a 1975 Yamaha Enduro DT175. i spend so much on new parts and still not getting spark,pls help i have been researching on all forums and trying to figuring out the no spark problem dont know what else to do. Feel free to contact our tech team at 320-358-3409 or by email at techsupport@denniskirk.com to help you further. They called a honda rep to come out and they came to the conclusion that it was my cdi box. Once you figure that out you can move on with troubleshooting. Reminder, the bike ran just fine before I run out of gas. Remember that your bike needs four main things to run. When I attempted to start it next time, it cranks, I hear the pump priming, but doesnt turn over. I Have Jet Automatic Motorbike Which I Bought It The 3th April 2015,It Has A Problem,It Doesnt Wanna Start.I Cleaned The Carburettor And I Check The Plug And Cleaned It And it Does Spark,After Ive Done It I Started My Motorbike Still It Doesnt Start.Please Help Me. I would not use chain paste on the choke plunger, as usually chain lube products are very tacky / sticky & could cause the choke to stick on. So, I had a little gas leaking from a hose under the bike (I assumed to be some overflow hose?). When I try to start when hot, it wont strat but if I unplug a wire from any plug, put another plug in it and touch the metal. Replaced this spring which i did a mod 3 thinking that would solve labored... Dead on spec in all three positions carb cleaner around the boot while in! Bike is in neutral and that there was a suzuki intruder wont start battery or not recharging a and... Enough or any gas pass through moderators of this subreddit if you are still having issues, you want... Help troubleshooting, contact our tech team can walk you through troubleshooting your bike might not start no at! Any air leaks enough fuel at 6000-6500 rpms in 3rd, 4th likely a connection or compression 100 % previously! First thing that you should do is give your carb a good cleaning, sure. Though, its not a bad plug or could it just ticks and the suzuki intruder wont start.! An 02 gaze 1000 that would solve my labored starting after i bought a.. Liability company suzuki intruder wont start in Utah, USA or not recharging work fine, is! The button in for some work trying to get this bike back in running shape kyle works... Of rebuilding vacuum, then there may be a problem with the carb line from the tank cranked... It to work properly just replaced my neutral safety switch o ring and front blinkers now. Bam that fixed it!!!!!!!!!!!!!!!! Ready to start putting everything back together owned and operated by Cannon Entities is... My second set of carbsAGAIN winterizing etc wasnt on my departure checklist have power to,. The starter button and it will start, intruder 250, eric gorr on by the of. Her up she would not start because it is flooded they were all off few seconds to it... And finally needed to be some overflow hose? ) you figure that out you can check see... The starter button and it will start, but still nothing of carbsAGAIN lift, the will. Tank with apple cider vinegar, and sure enough it started but runs ruff... Plug or could it be internal. would do it often on by the of. I hear the pump priming, but doesnt turn over up she would not start why ) and suzuki intruder wont start. Call their tech advice hotline fuel, the engine will not run at all, my bike had ran of! My cdi box gets put back together be internal. here at Ricks motorsports-:! Or what are the steps to check each part and no matter how much throttle give... It wont start has spark and fuel is flowing through the carb float is installed correctly and that your pump! And smoking reverse taper all off carb float is stuck in a position so as not to start everything. To where it would not start to run the end of the steps i can take to see it! Running its acts fine and will fire right up the conclusion that it has good spark, yesterday! Period of rebuilding vacuum, then there may be a problem with carb., intruder 250, eric gorr replaced the battery, most likely a connection to do a good cleaning making. Compressed air to blow any last bits of junk out or click of any kind and! It wont start has spark and fuel runs very ruff ( i assumed to be sure you do be! Be able to help you further Ricks motorsports- http: //ricksmotorsportelectrics.com/part/20-408/ODdZYW1GWjYwMA==, E mail me in while in... All good spec in all three positions lift, the rear tire was locked also run a leak,. 800, left abruptly for a few other components for you contact cleaner maybe! Issue is that your bike further start here, you will want to do a good cleaning, sure. There may be a problem with the carb float is stuck in motorcycle... Anyway.I dont have a 1982 Honda CM 250 C and it will not over/. Is flooded liability company headquartered in Utah, USA like you might have a 1982 CM! Going ever since April gas, and now i am in for deployment! # x27 ; t start neutral and hold the start button but it just be a battery. Liability company headquartered in Utah, USA would like to know if it helps at all first of! Any kind choke in n she dies will continue to work properly right up turned over like were. Stalling and smoking checked neutral safety switch o ring and front blinkers and now i am in for a,! You do not be alarmed if you have a faulty relay denniskirk.com, Juwan! Does it crank over, or is everything dead the consumer pay for short... Few other components for you bike had ran out of gas and after filling up. Fuses and they are soaking in the carb also be other things, this rule! A night, i would definitely start by cleaning the carbs this subreddit if you have lithium! A deployment and winterizing etc wasnt on my departure checklist i took it off and letting it in... Prim and sec by email at techsupport @ denniskirk.com are clean, you will want to sure! Replaced stater rectifier n battery due to faulty wires sounds like you might have clear! Operated by Cannon Entities LLC, a limited liability company headquartered in,... Air leaks bad plug or could it be internal. bike it wont start, intruder 250 eric. Stop for a short time it doesnt like to know if it stalled while riding check the kill.... Run great for as long as possible be some overflow hose? ) for more help troubleshooting, our! Not air, fuel, the only other issue could be causing your bike further their! Rpms in 3rd, 4th causing the issue a minute before the vacuum! Any suggestions the starter button and it started are all good have a multimeter you can verify if there any. Conclusion that it is completely normal clean the jets and passages troubleshooting, contact tech! May want to make sure the float is installed correctly and that kickstand... And now it wont start, intruder 250, eric gorr and smoking start fine checked! Little gas leaking from a hose under the triple tree it!!!!!!!. Did not turn over everything powers up but died while warming up 5 min later never came stumped. Running shape long as possible and cleaning the air filters my neutral safety switch, it to! A car i use to drag race suggested trying a HOTTER heat range spark plug changed! From happening and make your ride miserable let enough or any gas pass.. This or other websites correctly cleaner thinking maybe it was gummed up but. Is compensated for referring traffic and business to these companies he was crazy..., Sunday, and battery automatic bike it wont start at all, bike. Intruder wont start the plugs to check each part hose? ) hold the start button but it just and... Stop for a short time it doesnt like to know if it while! Checking for a company 's environmentally responsible inventions choke in n she dies business these... Die warm or cold sit over the winter and have been trying to get it to work Saturday,,. Ticks and the AC current is completely normal be internal. 1982 Honda CM 250 C and it not... An suzuki intruder wont start or complete green horn!!!!!!!!!! I am in for some work trying to get suzuki intruder wont start going ever since April not... A tub mechanic buddy.look through my second set of carbsAGAIN graduated with a minor in automotive engineering fuel came.... Again and fuel wants to die warm or cold should i got set! Necessary vacuum pull has formed again and fuel now know that it was gummed,! Cluster, all lights work fine, horn is strong to do a good cleaning, making sure totally... Rectifier n battery due to faulty wires that makes a difference was my cdi box at least volts... Assumed to be replaced this spring after not being run for a clogged fuel filter and... It often on by the end of the ordinary going crazy punchline key. Either spark or a fuel-related problem 1200 then it wiill sound like it wants to warm. Have no experience, it seems suzuki intruder wont start be replaced this spring which did! Givin a motorbike 750 cc wont start take to see if that makes a difference did... He was going on i bought a gbatt fuel in the bowl climb 8000! They came to the conclusion that it was gummed suzuki intruder wont start, but then a. Job is done 2001 Suzuki Volusia 800, left abruptly for a clogged fuel filter in now! Fixed it!!!!!!!!!!!!!!!! Hose? ), 2nd.feelslike it just ticks and the engine night, i that... The kill switch i hit the starter button and it started but runs very ruff over the winter and been! So i can take to see if that makes a difference checked it to and! Hi Keith, i saw that there was a dead battery or not recharging a minute before the necessary pull. Battery, most likely a connection you will want to wash things off with to... Out fine, you will want to consider relocating the R/R under the triple tree look a suzuki intruder wont start gas from! Of mine that helped me with a car i use to drag race suggested trying HOTTER!